Professional Documents
Culture Documents
Formwork Procedure
Formwork Procedure
Formwork Procedure
COMPONENTS
•START USING
THE SIDE PCS
SIDE: 8 x 80 inch plywood
3 of the 5 inch
length 2 x 4
2 of 72 inch
length 2 x4
START BY PUTTING
THE 72 INCH 2 X 4
ON THE GROUND
•POSITION THE
PLANKS
•TOP, BOTTOM
AND MIDDLE
NEXT
SINCE IT’S A 72
INCH LENGTH THE
MIDDLE IS 36
INCHES
PUT THE CLAMP AT THE MIDDLE
THEN DRILL ( MIDDLE)
TOP
BOTTOM
TO CONNECT THE
2 X 4 TO ANOTHER
2 X 4 YOU NEED A
LONGER SCREW.
SCREW FROM THE TOP
•IT MIGHT TWIST A
LITTLE BUT ITS OK
REMOVE THE CLAMP
ROTATE AND SCREW
DO THE SAME AT THE BOTTOM
Get your 8 x 80 plywood
Put the rough side down
Should have 4 inch over length on each side
Drill 6-8 holes
Start putting screws
Notice that there is a 4 inch over length on
both ends
•Do that again
and make 2 of
them
The remaining pc you need to make
6 x 8 plywood
2 PCS 8 INCH LENGTH 2 X4
(you need to make 2 of these)