Professional Documents
Culture Documents
Mediatek Dimensity G99 Flashing
Mediatek Dimensity G99 Flashing
Internal Use
2020/08/17
ST
Copyright©©MediaTek
Copyright MediaTekInc. AllAll
Inc. rights reserved.
rights reserved.
Internal Use
Content
▪ Feature introduction
▪ Scan com port
▪ Image checksum verify
Feature introduction
Copyright©©MediaTek
Copyright MediaTekInc. AllAll
Inc. rights reserved.
rights reserved.
Internal Use
Feature introduction
▪ Get started
▪ Download Type
▪ Download speed
▪ Battery option
▪ Auto polling
▪ Checksum level
Internal Use
Get started
▪ Step1: make sure the scatter_checksum.xml of SW image has been generate
▪ Step2: select flash.xml
▪ Step4: configure the battery option
▪ Step5: select how many phones to download at the same time
▪ Step6: Scan com port
▪ Step7: click the start button to download
▪ Step8: plug in the phone which has been powered off
Internal Use
2
Internal Use
step2
step5
step3
step6
step4
Internal Use
Download Type
▪ Firmware upgrade
– Calibration data will be keeped, other partition will be format
and download all the image
Internal Use
Battery option
▪ Battery
– The power support sourc is battery
▪ No battery
– The power support source is usb, tool will enable charger to
get power from usb
▪ Auto detect
– Tool will detect if battery exists, then choose which power
source
if yes, choose battery
if not, choose usb
Internal Use
Auto polling
▪ If enable, the tool will start the download again
automaticly each time finishing the download.
Internal Use
Copyright©©MediaTek
Copyright MediaTekInc. AllAll
Inc. rights reserved.
rights reserved.
Internal Use
▪ Principle :
– When plug in usb cable, the tool scan com port first and get the usbport cable
ID; and then save the cable ID into the SP_MultiportDownload.ini
Copyright©©MediaTek
Copyright MediaTekInc. AllAll
Inc. rights reserved.
rights reserved.
Internal Use
2
Internal Use
(2) Open “mdt_setting.ini” in tool folder; set BlowAfterDownload = true and config the EfuseImagePath;
after that the tool will write eFuse after format and download ;
(3) If you need to read efuse ; you can set ReadEfuseEnable = true ,and config the ReadbackPath
InternalUse
Internal Use
Thanks
Copyright©©MediaTek
Copyright MediaTekInc. AllAll
Inc. rights reserved.
rights reserved.