Professional Documents
Culture Documents
Side Drawing Support Sheet
Side Drawing Support Sheet
Side Drawing Support Sheet
Machine
Skills Year 7
Step one Check material
You will cut out 3 pieces from this larger piece
Measure – L=200mm x W-52mm x D-10mm Side(s)
• From the LHS measure 200mm place a mark on the wood next to 200mm on the
ruler THEN another mark at 210mm
• Use your Try square now
• Now measure another 200mm from the last line you drew.
• Make another mark at 210mm again Use your Try square again
• Make another mark at 100mm from the last line you drew
• Use your Try square again
Step two • Now draw all around your PINE material connecting all the lines around the piece.
• Collect a Tenon Saw and a Bench Hook and cut BETWEEN the LINES
• Cut all 3 pieces
Collect tools:
Step three • Collect Goggles and take your pieces to the Sanding machine
Safety & • Sand your material until you reach the line you marked earlier. NO FURTHER • Tenon Saw
Quality control • Safety and Accuracy here is important • Try square
• Steel rule
Step four • Measure down from the small width end ( W-52mm) 60 mm on the steel rule put a
mark on the pine wood. • Bench hook
• Draw a line through the mark using your try square
• Using the steel rule Measure along this line 26mm put a mark (under tables)
• This will become a hole
• Repeat this on the other piece.
200mm
Step
three:
Step four:
26mm
60mm