& they “look” nice, but they will not export! Step 9.1 – Drawing Actual Threads
• Let’s Make Some Actual Cut Threads in a 3D
Model. Step 9.2 – Drawing Actual Threads • This is a 3/8th Bolt, it has a 3” long fully threaded shank, with threads of 3/8th-16, Head of the bolt is 9/16” Step 9.3 – Bolt Part Names/Terms
• Any 2 parts that need to go together & move Need a GAP! Step 9.4 – Thread Pitches
• So, our 3/8th-16 = a 3/8th diameter
with 16 threads per inch. Step 9.5 – Content Center
• You won’t make nuts & bolts often, standard sizes
of nuts & bolts are available in the content center. Step 9.6 – When You Need This! • Sometimes you will have to draw a special nut &/or bolt. • Most often you’ll be cutting threads in bolt holes all over your part! Like the 100 threaded bolt holes on this engine block! Step 10.1 – 3/8 Bolt Shaft
• Made a 3/8” Bolt Shaft 2” Long
Step 10.2 – 3/8 Bolt Shaft
• Select a plane that intersects like so…
Step 10.3 – 3/8 Bolt Shaft
• Put a Sketch on that plane.
• I’m naming it 16 Pitch Thread Sketch Step 10.4 – The F7 Button
• The F7 Button will “Cut” the part in half along the
sketch you are in. Let’s you draw inside the part!