Professional Documents
Culture Documents
Taper Cut Cone
Taper Cut Cone
Taper Cut Cone
1. BMXP software take the bottom level of work piece as program level.
2.Before Taper Cutting, must check wire vertical.
3.Before 1st Taper Cutting, must make a test cutting to correct H1 and H2 size
Pre-Step 2.2
Create Path 1
Offset: 0 , None
After you install machine or after you change the Z axis position
(raise or lower the up frame), Before 1st time Taper Cutting,
you must check wire vertical and correct H1 & H2,
Pre –Step 1, adjust the wire, make sure the wire is vertical to the
program level
Then Click OK
4./ Start Cutting
Click “OK”
Pre-Step 2.8
Taper Calculate
Real Bottom Circle Diameter
1./ Menu “BMXP” >> ”Taper Calc”
Real Top Circle Diameter
New H1
2./ Input All data then click button
“Calc”
After Test Cutting, now you can start formal Taper Cutting.
Ok, check the height from work piece bottom to taper start
level , name is Hx, plus it to H2
+ 3 degree - 3 degree
Over Degree or Over Height
Thank you take time reading!!