Professional Documents
Culture Documents
QUIZ FOR MODULE 1.2
QUIZ FOR MODULE 1.2
QUIZ FOR MODULE 1.2
FOR
MODULE 1.2
1. Which of the following denotes product
functionality and safe operation?
A. Low cost
B. Reliable
C. Good Quality
D. Suitable for the application
2. Which step in material and product
inspection where random pull out of
sample is required?
A. Humidity
B. Thermal Shock
C. Flammability
D. Vibration
4. It is a device that limits or resists
current in a circuit.
A. Capacitor
B. Transistor
C. Semiconductor Diode
D. Resistor
5. What type of defect could adversely
affect the function and performance of the
products/components?
A. Minor Defect
B. Critical Defect
C. Major Defect
D. None of the above
6. Which of the following is not a reason for
conducting an inspection?
A. to prevent further work being done on pieces
already spoiled
B. to have evidence when you complain of any
defect found
C. to avoid using defective and damages products
D. to detect and isolate faulty materials, or work
and so to prevent this waste
7. Which document describes the materials,
including their requirements for storage,
tolerances, shelf-life, specifications, name
of supplier and safety data.
A. Test specification
B. Material specification
C. Quality specification
D. Design specification
8. What device that stores electrons and is
made up of two conductors separated by an
insulator or dielectric?
A. Capacitor
B. Transistor
C. Semiconductor Diode
D. Resistor
9. What type of defects is considered as
completely unusable and/or could cause
harm to the user or someone in the vicinity
of the product?
A. Major Defect
B. Critical Defect
C. Minor Defect
D. None of the above
10. What is the most important factor when
choosing materials to buy?
A. Low cost
B. Reliable
C. Good Quality
D. Suitable for the application
ANSWER KEY:
1. C 6. C
2. A 7. C
3. D 8. D
4. B 9. B
5. C 10. D