Professional Documents
Culture Documents
ICEM-Intro 13.0 WS3.2 Wingbody Shell
ICEM-Intro 13.0 WS3.2 Wingbody Shell
ICEM-Intro 13.0 WS3.2 Wingbody Shell
Workshop 3.2
Shell Meshing Wingbody F6 Model
WS3.2-1
WS3.2-2
Mesh Setup
Need to set Mesh Methods, Types and Sizes:
First set global settings
Mesh > Global Mesh Setup > Global Mesh size
Set Max element size to 1000 Maximum allowable mesh size in model
WS3.2-3
Right mouse select until Geometric 2 appears Increment with left mouse (over number) to 1.2
ANSYS, Inc. Proprietary 2010 ANSYS, Inc. All rights reserved.
WS3.2-5
Some curves have a reversed direction than the one we copied from
In this case two bottom end curves as shown Go back to Dynamic method
Reverse (right mouse on curve) or decrease Bunching ratio number to 1.0 Bunching law changes to Geometric 1, when the ratio reaches 1 Left mouse key to increase to 1.2
ANSYS, Inc. Proprietary 2010 ANSYS, Inc. All rights reserved.
WS3.2-6
WS3.2-7
WS3.2-8
Delete Mesh
Delete bad mesh
Turn off FARFIELD, INLET, OUTLET
To be able to select mesh behind them
Select Edit Mesh > Delete Elements and select one of the elements on each surface as shown Select up to a curve in Select mesh elements toolbar or r on the keyboard to flood-fill all other elements on those two surfaces
Flood fills to boundary curves making up loop Middle mouse or Apply
WS3.2-9
Compute
ANSYS, Inc. Proprietary 2010 ANSYS, Inc. All rights reserved.
WS3.2-10
Final Mesh
Observe revised surface mesh Note mapped (aligned) mesh along leading edge (front of wing)
Save Project!
WS3.2-11